After rapid gains from vertical tillage, pH and fertility, the improvement pace slows down.
Another year of results from a long-term comparison of healthy and unhealthy soil in central Illinois confirms the trend:¬†
- Improvements in soil health can be documented in just a few years, enough to move yields from unprofitable to profitable.
- The fastest improvements involved fertility and pH (the chemical aspect of soil health) and eliminating compaction (the physical aspect).
- Improvements in the biological aspect of soil health take longer.
- Restoring abused soil to health might take a very long time.
This past year‚Äôs results provided more good news‚Äîbut the improvements were less dramatic than Farm Journal Field Agronomist Ken Ferrie,¬†who is conducting the study, had hoped. The 2016 results showed, in some situations, even small soil health improvements from a single year of cover cropping might impact yield.¬†
The study involves two farms about a mile apart‚ÄîFarm A and Farm B. Both farms primarily contain two types of soil. One is a lighter silt loam, with about 3% organic matter content and a cation exchange capacity of 15 to 16. The other is a heavier silty clay loam. The organic matter content of that soil is 4% or more, and the cation exchange capacity is 20 to 25. If both soils were in perfect health, the silty clay loam would always outyield the silt loam because it has higher natural fertility and water-holding capacity.
The soil on Farm A has always been well-cared-for and healthy, but Farm B had been abused for 30 years, resulting in unhealthy soil. The practices used on both farms were similar except the operator of Farm A no-tilled. The operator of Farm B disked soybean stubble before planting corn, which destroyed soil structure and left an impermeable compaction layer.
The soil on Farm B also had become very acid. Because of these factors, the unhealthy soil on Farm B had more erosion, slower decomposition of residue and poor water infiltration.
In 2011, the new operator of Farm B set out to restore its soil health. He used vertical tillage to remove sudden density changes and compaction. He also aggressively applied lime to build up soil pH. Ferrie calls that ‚Äúshooting the slow rabbits first‚Äù because these changes are the easiest to make and they produce quick improvements in soil health and yield.¬†
‚ÄúThe vertical tillage used to fix physical problems helped incorporate some of the lime into the soil profile,‚Äù Ferrie says. ‚ÄúAs we got soil pH somewhat tamed, the operator moved back to no-till, which he prefers. Since we were no longer incorporating lime, we had to reduce the amount applied and apply it more often.‚Äù¬†
On the fertility side, everything involves the 4Rs‚Äîright product, right rate, right time and right place. ‚ÄúWe have implemented variable-rate fertility, including applying some with the planter and sidedressing some of the nitrogen,‚Äù Ferrie notes.
Restoring soil health is complicated because the physical, chemical and biological aspects are interrelated. For example, the acid soil required high rates of lime, but you can‚Äôt add lime without tying up some phosphorus, Ferrie says. ‚ÄúMuch of nutrient variability is controlled by soil microorganisms, the biological aspect of soil health.‚Äù
Shooting the slow rabbits of compaction and acidity produced quick results. The corn yield on Farm B‚Äôs silty clay loam rose from an average of 130 bu. per acre between 2008 and 2010 to 225 bu. in 2013 and 215 bu. in 2015. (The farm is in a corn/soybean rotation.) On its silt loam, yield increased from 123 bu. per acre from 2008 through 2010 to 215 bu. in 2015. The yield improvement was enough to make the farm profitable.¬†
However, Farm B‚Äôs corn yield still lags 20 bu. to 30 bu. per acre behind Farm A.¬†
Now comes the hard part: continuing to improve the chemical and biological aspects of Farm B‚Äôs soil health. ‚ÄúBecause the soil was acid for so long, and subjected to too much tillage, much of Farm B‚Äôs soil structure has been destroyed,‚Äù Ferrie says. ‚ÄúWe can‚Äôt fix structure with a single treatment‚Äîalthough the lime we‚Äôve applied helped because the calcium flocculates clay particles (while the carbonate corrects acidity).‚Äù¬†
Poor structure causes soil particles to run together and seal. That leads to erosion and surface crusting, which causes stand problems.
‚ÄúWhile corn‚Äôs grassy roots might help build soil structure, the soybeans in Farm B‚Äôs rotation don‚Äôt help much,‚Äù Ferrie says. ‚ÄúWe realized we had to add wheat or a grass cover crop to the rotation for continued improvement.‚Äù
The farmer chose a grass cover crop. Flying annual ryegrass seed into soybeans in 2014 sounded promising; but, for reasons not fully understood, the cover crop failed to establish.¬†
In fall 2015, the farmer harvested some of the corn early (4% more moisture than the rest of the field) and drilled cereal rye into the stalks. ‚ÄúThe timely seeding produced a good stand,‚Äù Ferrie says. In spring 2016, they¬†no-tilled soybeans into the cereal rye.¬†
In the more productive silty clay loam, the cover crop had no effect on yield. But in the less productive silt loam soil, in two locations within the field, there was an impact. In the first location, the cover cropped portion yielded 58 bu. per acre and the no-cover portion yielded 56 bu. In the second location, the cover cropped strip produced 55 bu. per acre, compared with 54.6 bu. without a cover crop.¬†
Attempting to explain the yield effect, Ferrie ran several soil health tests. The results for the water-soluble (ortho) phosphorus and aggregate stability tests provided a clue.¬†
‚ÄúWater-soluble phosphorus is a pretty good indicator of biological health,‚Äù Ferrie says. ‚ÄúThe increase from 1 ppm to 2 ppm at the first location is significant.‚Äù ¬†¬†
Aggregate stability also improved under the cover crop. But Cornell University‚Äôs Comprehensive Assessment of Soil Health scores both areas under 20, on a scale of 100, which is considered very low. In contrast, Farm A‚Äôs health was rated 80. (See table below.)
‚ÄúAlthough the improvement in aggregate stability was small, the score did move in the right direction,‚Äù Ferrie says. ‚ÄúEventually, improvements in aggregate stability should result in improved water infiltration, and we‚Äôll see improvement elsewhere, such as in the soil‚Äôs carbon/nitrogen ratio.‚Äù¬†
The 2016 yield increase was not enough to pay for the cost of the cover crop (drying the early harvested corn, planting the cover crop and terminating it in the spring), Ferrie notes. ‚ÄúBut at least it wasn‚Äôt a yield drag,‚Äù he adds.
A cereal rye cover crop was seeded in fall 2016. This spring, the operator will strip-till corn into the cover crop.¬†
‚ÄúWe hope to keep the ball rolling, in terms of soil health improvement,‚Äù Ferrie says. ‚ÄúThis past year‚Äôs results were encouraging but also disheartening because soil health is not improving as fast as I had hoped. Still, we proved we could make the farm profitable in just a few years.‚Äù ¬†
Building on the Systems Approach, the Soil Health series details the chemical, physical and biological components of soil and how to give your crop a fighting chance. To learn more about this multiyear effort to nurture sick soil back to health, visit¬†www.FarmJournal.com/soil_health